Cornelius REMCOR 1550 Manual de usuario Pagina 1

Installation Manual1550 UNIVERSAL BEER DISPENSER(R-404A REFRIGERANT)PRINTED IN U.S.AIMI CORNELIUS INC; 1998–99IMI CORNELIUS INC g One Cornelius Pla

6569000246THIS PAGE LEFT BLANK INTENTIONALLY

7 569000246INSTALLATIONThis section covers unpacking and inspection, selecting location, installing Unit, preparing for operation, andoperation.UNPACK

85690002462. The Unit must be installed near a properly grounded electrical outlet with proper electrical require-ments.The electrical circuit must be

9 5690002466. Make sure the main power switch (115 VAC, 60 Hz Unit), located on back side of the Unit, is in the “OFF”(down) position.7. Plug Unit pow

105690002463. Open the CO2 cylinder shutoff valve slightly to allow the primary CO2 regulator to fill with gas, then openthe valve fully to back-seat

56900024611OPERATOR’S INSTRUCTIONSThis section covers operating controls, pre-operation check, Unit operation, and maintenance procedures thatmay be p

569000246 12BEER FAUCET (2)UNIT POWER SWITCH(115 VAC, 60 HZ UNIT ONLY)DRIP TRAY/CUP RESTFIGURE 3. 1550 UNIVERSAL BEER DISPENSEROPERATING CLEARANCESChe

56900024613 An excessive accumulation of dust, lint, and grease on the condenser coil will restrict air flow through the coilwhich will decrease cooli

i569000246TABLE OF CONTENTSPageSAFETY INFORMATION 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

569000246 14THIS PAGE LEFT BLANK INTENTIONALLY

56900024615SERVICE AND MAINTENANCEThis section describes the service and maintenance procedures to be performed on the Unit.IMPORTANT: Only qualified

569000246 16UNIT BEER INLETLINES (2)POWERCORDTOP COVERBEER FAUCET (2)CUP RESTDRIP TRAYAIR INTAKERETAININGSCREW (4)ACCESS GRILLE (4)DRIP TRAYDRAIN HOSE

56900024617BEER INLETLINES (2)ELECTRICALCONTROL BOXPOWER CORDRETAININGSCREWTERMINALBLOCKCONDENSERCOILUNIT POWERSWITCH(115 VACUNIT ONLY)COMPRESSORCONDE

569000246 18Adjusting Beer Kegs Secondary CO2 Regulators.Beer kegs secondary CO2 regulators pressures adjustments require calculations of each beer sy

569000246192. Remove four screws securing air intake grille on the Unit front panel, then remove the grille.3. Vacuum or use a soft brush to clean the

569000246 208. Using a fiber brush, carefully clean mineral deposit build-up from the agitator motor shaft and the ice banksensing bulb.9. Rinse all p

569000246215. Connect tank containing detergent solution into the beer system.6. Place waste container under applicable beer faucet.7. Activate the be

569000246 22WARNING: CO2 displaces oxygen. Strict attention must be observed in the prevention ofCO2 (carbon dioxide) gas leaks in the entire CO2 and

56900024623CLEANING CO2 GAS CHECK VALVE(see Figures 2 and 7) CO2 gas check valves must be inspected and serviced at least once a year under normal con

ii569000246TABLE OF CONTENTS (cont’d)PageSERVICE AND MAINTENANCE 15. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

569000246 24FIGURE 8. WIRING DIAGRAM

25 569000246TROUBLESHOOTINGIMPORTANT: Only qualified Personnel should service internal components or electrical wiring.WARNING: If repairs are to be m

26569000246Trouble RemedyProbable CauseDISPENSED BEER FLOWRATE TOO HIGH.A. Beer faucet not properlyadjusted for beer flow rate.A. Adjust dispensed bee

27 569000246Trouble Probable Cause RemedyTROUBLESHOOTING COOLING UNIT REFRIGERATION SYSTEMCOMPRESSOR DOES NOTOPERATE.A. Glycol (coolant) sufficientlyc

28569000246Trouble RemedyProbable CauseREFRIGERATIONCOMPRESSOR NOTOPERATINGA. Refrigeration systemoverheated. Cloggedcondenser coil air intake filter

29 569000246IMI CORNELIUS INC.ONE CORNELIUS PLACEANOKA, MN. 55303–6234TELEPHONE (800) 238–3600FACSIMILE (612) 422–3232WARRANTYIMI Cornelius Inc. warra

IMI CORNELIUS INC.CORPORATE HEADQUARTERS:One Cornelius PlaceAnoka, Minnesota 55303-6234(612) 421-6120(800) 238-3600301137000

1 569000246SAFETY INFORMATIONRecognize Safety InformationThis is the safety-alert symbol. When you see thissymbol on our machine or in this manual, be

2569000246THIS PAGE LEFT BLANK INTENTIONALLY

3 569000246GENERAL INFORMATIONIMPORTANT: To the user of this manual – This manual is a guide for installing, operating, and main-taining this equipmen

4569000246Table 1. Design Data (cont’d)Electrical Requirements:Operating Voltage See Unit NameplateCurrent Draw See Unit NameplateTHEORY OF OPERATION(

5569000246CO2 GASCHECK VALVE (2)BEER KEG (2)CO2 CYLINDERLINE LEGENDBEERCO2PRIMARY CO2REGULATORBEER KEG SECONDARYCO2 REGULATOR (2)CO2 SHUTOFFVALVE (2)B